|
|
|
FORD BRONCO
-> FUEL SYSTEM; carbs, EFI, pumps, tanks, propane, ...
|
|
WELCOME to MIESK5's BIG BRONCO LINKS
This is a Ford Bronco, Truck & Van Technical, Parts & Vehicle Classifieds LINKS site developed by the MIESK5 Family and is not affiliated with the Ford Motor Company in any manner.
Although we initially developed this site for 78-96 Big Broncos, information in many Links also applies to Ford Trucks, Vans & Cars.
|
| Select A Category: |
|
California ReFormulated Gasoline (CaRFG) TSB 96-10-07
|
|
Cap, including emissions types
|
|
Carburetor & Microprocessor Control Unit (MCU)
|
|
Electronic Fuel Injection (EFI) - Mass Air Flow (MAF), Speed Density, Filter, Fuel Injection, Non-Warranty Reimbursement Testing TSB 98-9-9 for 92-96, Fuel Injector, Fuel Pressure Regulator (FPR), Pump & Relay, Fuel System Monitor, Inertia Fuel Cut-Off Switch, Swaps, Throttle Body
|
|
Fuel & Emission Parts Catalog, Ford
|
|
Fuel Filler & Oil Filler Caps, Parts Catalog, Ford
|
|
Fuel Volatility TSB 98-26-2 for 87-96
|
|
General Information
|
|
Line & Hose
|
|
Propane Conversion
|
|
Recalls
|
|
Sea Foam®
|
|
Tank, including EFI type & Floor Pan Cut-Outs
|
|
Throttle Cable
|
|
Throttle, including hand & brake
|
| Select A Link: |
|
Auto Repair Reference Center Repair Manual, Mostly Chilton; many local library's offer free online access for their members; just log-in w/your library Card # and password; incl. all Broncos, & many MAKES! 1951 to 2009; some years (85-96, I believe) include: FULL Technical Service Bulletins and Recalls, Labor Hours per repair (plug in appl info); Wiring Diagrams, Vacuum Diagrams (in DRIVEABILITY AND EMISSIONS CONTROLS Section), Specifications (torques, etc.) & Maintenance Intervals
Source: by arrc.epnet.com
|
Chilton Manual for 66 - 81 Bronco, Scanned Copy
Source: by Chilton via broncocity.com
|
Fuel Saving Tips, General; "...Under inflated tires Increase rolling resistance 1-2 mpg; Dirty air filter Causes excessively rich fuel/air mixture 2.0 mpg; Worn spark plugs Cause inefficient combustion, wasted fuel 2.0 mpg; Worn O2 sensor Unable to detect and adjust air/fuel mixture 3 mpg; Dirty or substandard engine oil Increases internal engine friction 0.4 mpg; Loose gas cap Allows fuel to evaporate 2.0 mpg; Potential loss in fuel economy if all of the above were neglected 11.4 mpg..."
Source: by crownautopartsinc.com
|
Fuel System Related Repair Labor Times in 84-96
Source: by Airtex at showmetheparts.com
|
Fuel System TECHNICAL SERVICE BULLETINS (TSBs) in Full; Agree and enter year, make/model, etc.
Source: by Airtex at showmetheparts.com
|
Fuel System Wiring Diagrams & Component Location Diagrams in 86-96 Bronco & Fords; Agree and enter year, make/model, etc.
Source: by Airtex at showmetheparts.com
|
High Idle & Dieseling Troubleshooting Chart in a 94, from PCED Chart 7 for a 94; Preliminary Checks; Vacuum Leaks, Throttle Plate & Linkage, Speed Control Chain Binding/Sticking, Air Intake Tube/ Intake Manifold Leaks..." READ MORE
Source: by Ford via Steve83 (Steve, That dirty old truck) at SuperMotors.net
|
Leak Detection with UV/blue light, General (mostly ad, but good DIY info tips)
Source: by tracerline.com
|
Microprocessor Control Unit (MCU) Overview; "...The Microprocessor Control Unit (MCU) system was used on most 1981–83 carburetor equipped vehicles, and 1984 and newer V8 engines with feedback carburetors. The MCU system uses a large six sided connector, identical to the one used with EEC-IV systems. The MCU system does NOT use the small single wire connector, like the EEC-IV system. This system has limited ability to diagnose a malfunction within itself. Through the use of trouble codes, the system will indicate where to test. When an analog voltmeter or special tester is connected to the diagnostic link connector and the system is triggered, the self-test simulates a variety of engine operating conditions and evaluates all the responses received from the various MCU components, so any abnormal operating conditions can be detected.Diagnosis of a driveability problem requires attention to detail and following the diagnostic procedures in the correct order. Resist the temptation to begin extensive testing before completing the preliminary diagnostic steps. The preliminary or visual inspection must be completed in detail before diagnosis begins. In many cases this will shorten diagnostic time and often cure the problem without electronic testing..." READ MORE for Reading Codes & Diagnostic Trouble Codes (DTC's)
Source: by Ford via arrc.epnet.com
|
MPG Improvement Tips
Source: by 96GreenMonster at FSB
|
Repair Locations Grid & Coding, Bronco; used to pin-point location of a repair or component in a vehicle
Source: by Ford via Steve83 (Steve, That dirty old truck) at SuperMotors.net
|
TOP TIER Gasoline Retailers; Gasoline retailers must meet the high TOP TIER standards with all grades of gasoline to be approved by the automakers as providing TOP TIER Detergent Gasoline.
Source: by toptiergas.com
|
Vacuum Leak Symptoms, General; "...Too fast an idle speed; A rough idle or stalling; Hesitation or misfiring when accelerating; An idle mixture that defies adjustment (carburetor)
Source: by aa1car.com
|
Wiring Diagrams in an 86 Ford truck; Many Diesel Engine Systems & Components
Source: by Agnem (The Moosestang) at webshots.com
|
|
|
